| ENGINE:Gasoline engines - Cylinder block and all internal lubricated parts
including: crankshaft, rod and main bearings, cam bearings, expansion
(freeze) plugs, connecting rods, wrist pins, pistons, piston rings,
camshaft, cam tower, lifters, cylinder head, valves and guides, valve
springs, rocker arms/cam followers, pushrods, timing chain housing,
timing chain and sprockets, timing belt and pulleys, timing belt
tensioner, intake and exhaust manifolds, flywheel, balance shafts,
harmonic balancer and retainer bolt, crankshaft pulley, valve covers,
oil pan, oil pump and pressure relief valve, engine oil cooler hoses,
oil filter adapter/housing, engine oil sending unit, engine mounts,
water pump, temperature sending unit, thermostat and housing, fuel
supply pump, vacuum pump, dipstick and tube, fasteners for the
components listed above.
Turbocharged/Supercharged/Rotary/Diesel/Enhanced Engines - All of the above listed parts or equivalent plus: turbocharger, waste gate controller, intercooler, hard lines, compressor, clutch and pulley, bypass valve, injection pump, lines and nozzles.
|TRANSMISSION: Automatic - Case and all internal lubricated parts including: oil pump, valve body, torque converter, vacuum modulator, governor, main shaft, clutches, bands, drums, gear sets, bearings, bushings, sealing rings, transmission mounts, cooler, cooler hoses and hard lines, dipstick and tube, fasteners for the components listed above.|
| FRONT/REAR WHEEL DRIVE:
Front Rear Drive - Final drive housing, and all internal parts including: carrier case, gear sets, chain and sprokets, bearings, bushings, axle shafts, universal joints, front hub bearings, locking hub assemblies (4x4), drive shaft support, rear axle hub bearings, fasteners for the components listed above.
Rear Wheel Drive - Drive axle housing, and all internal lubricated parts including: carrier case, gear sets, bearings, bushings, limited slip clutch pack, axle shafts, axle bub bearings, propeller shafts universal joints, drive shaft support, front axle hub bearings, fasteners for the components listed above.
Housing/case and all internal lubricated parts including: rack and pinion equipped valve assembly, sector shaft, rack mounts and cushions, inner rod ends and bellows boots, speed sensor or steering gear equipped pitman shaft and valve assembly, sealing rings, bearings, bushings, pitman arm, center link, tie rods, idler arm, power steering pump and pulley, fluid reservoir, pressure and return hoses, cooler and hard lines, power cylinder assembly, sterring main and intermediate shafts, coupling, seals and gaskets, fasteners for the components listed above.
| FRONT SUSPENSION:
Upper and lower control arms, bump stop cusions, control arm shafts torsion bar mounts and bushings, upper and lower ball joints including: dust boots, steering knuckle (spindle), wheel bearings and seals, stabilizer shaft, stabilizer linkage including: mounts and bushings strut rods and bushings, king pins, seals and gaskets, fasteners for the components listed above.
Master cylinder, assist booster, wheel cylinders, combination valve, disc brake calipers (and rear caliper actuators), hard lines and fittings, backing plates, springs, clips and retainers, self-adjusters, parking brake linkage and cables, seals and gaskets, fasteners for the components listed above.
| SEALS AND GASKETS:
All seals and gaskets on the assemblies listed for engine, transmission, front and rear wheel drive, steering, front suspension, and brakes.
Alternator, voltage regulator, windshield wiper motors and delay controller, starter motor and drive, starter solenoid, wiring harnesses, manually operated switches (such as turn signal, headlight, dimmer, and wiper switches), mechanically actuated switches (ignition, brake light, and neutral safety switch), electronic fuel injection (specifically sensors, pressure regulators, fuel rails, injectors, seals and gaskets), electronic fuel pump, electronic ignition module, distributor and coil, engine management control unit, knock sensor and oxygen sensor.
Compressor and mounting brackets, clutch and pulley, condenser, evaporator, orifce tube, POA valve, accumulator, temperature control programmer, high/low pressure cutoff switches, high/low pressure hoses, pressure cycling switch, termostat, drier, temperature control head, o-ring seals, gaskets, fasteners for the components listed above, and freon-refrigerant if necessary in conjunction with the repair of the components listed above.
HIGH TECH (not included in silver or bronze plans):
Vital Systems - Electronic fuel injection, anti-lock brakes, heater core assembly, heater control valve, horn assembly, constant velocity joints
Power Components - Seat motors and transmissions, window motors and regulators, door lock actuators, sunroof motor, heated back glass.
Displays and Sensors - Digital and analog instruments, low fuel, coolant and oil sensors, temperature sensor and relay
Motors - Electronic rearview mirrors, headlight doors, windshield wiper washer pumps, heater-A/C blower, convertible top motor
Fuel & Cooling - Radiator, radiator fan and clutch, radiator fan motor, fan blade, fuel tank and hard lines, fuel tank sending unit.